Key Takeaway
POWER SLIDING DOOR WIRING HARNESS ASSEMBLY by VOLKSWAGEN OF AMERICA, INC was recalled on June 10, 2010. What to do: VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NE...
POWER SLIDING DOOR WIRING HARNESS ASSEMBLY
Description
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.
Injuries / Consequence
THIS COULD RESULT IN AN OVERHEATED LATCH AND A FIRE WITHIN THE REAR SLIDING DOOR COULD OCCUR.
Remedy
VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Products Affected
Vehicle
VehiclesCompany Information
VOLKSWAGEN OF AMERICA, INC
Unknown location
View all 74 recalls by VOLKSWAGEN OF AMERICA, INC →Related Recalls
Loss of Brake Assist due to Booster Contamination
August 26, 2014
Bubbles in Fuel may Result in Engine Stall
July 21, 2014
Front Stabilizer Links may Detach
July 9, 2014
Ignition Switch may Turn Off
July 3, 2014
Oil Leak at Transmission Oil Cooler
April 15, 2014
Loss Of Low Beam Headlight
March 19, 2014
Frequently Asked Questions
Is this recall still active?
Check the status badge at the top of this page. "Ongoing" means the recall is still active and you should follow the remedy instructions. "Completed" or "Terminated" means the recall process has concluded, though the safety issue remains relevant for any unrepaired products.
How do I check if my product is affected?
Compare the model number, lot code, serial number, or date range listed in the recall notice with the information on your product's label or packaging. For vehicles, check your VIN at NHTSA.gov/Recalls.
What remedy is available for this recall?
The listed remedy for this recall is: VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND...
Where can I find the original recall notice?
This recall was issued by NHTSA. You can view the original notice using the link provided above.